Engine
Inspecting the Voltage Regulator BEFORE it Fails and Leaves You Stranded
Do it very soon unless you know it have been done within the last 50,000 miles.
What's wrong with my Mercedes?
Engine Problems
Engine
Engine or Climate Control Heater not Getting Hot
It is almost always a failed thermostat
Engine
Diesel Engine Oil Leaks
Most of those annoying leaks can be fixed with our DIY kits
Engine
Preventing Bolt or Thread Seizure
A special compound should be used - especially with steel bolts in aluminum threads
Engine
Keeping the Power Steering Fluid Clean
Many are surprised to learn there is a filter down inside the pump
Engine
Worn Timing Chain and Guides
Failure of these chains can lead to catastrophic engine failure
Engine
Engine Won't Start? Could It Be the Distributor Cap?
You would be amazed at the pesky problems these can create!
Engine
Challenges When Doing Valve Adjustment on Early Gas Engines
Special tools are needed but you can still run into problems
Engine
Troubleshooting Diesel Engine Overheating
It could be a number of things causing the problem. Follow Kent's video series
Engine
How to Determine the Real Condition of a Used Engine
It is best if you can see and hear it run - if not some tests are essential
Engine
Badly Pitted Water Pump or Thermostat Housing Hose Nipple
If you don't fix it the problem will get worse and the coolant hose will leak
Engine
Checking for Slow Power Steering Fluid Leaks
Check Your Low Pressure Power Steering Pump Hose
Engine
Diesel Injectors Still Not Working Properly After Rebuild
It is not the problem with the new nozzle - there are other issues that cause poor spray
Engine
Cleaning Old Engine Aluminum Parts
How can you do it without removing them from the engine?
Engine
Leaking Mufflers and Exhaust Pipes
If not too far gone you can fix them - and yes it is a miracle!
Engine
Should I Buy a Cheap Mercedes?
6 part video series on reasons why you should or shouldn't
Engine
How to Easily Add Life to Your Old Benz
You can do it with magnets!
Engine
Fan Belt Noises
They can be a little tricky to isolate
Engine
Rotating Your Engine During Service and Maintenance
Best done from the front crankshaft bolt
Engine
Using the Wrong Gasket Sealant
If you use RTV you can create some real problems
Engine
How to do OVER THE TOP Engine Compartment Detailing
It takes work but with the right products and techniques you will be amazed
Engine
Worn Out Engine Motor Mounts
How to determine if they need replacement
Engine
How to Tell if Your Thermostat is Failing?
Monitor your engine temperature gauge in the morning for telltale signs.
Engine
Loose Alternator Belt on 1970's Models
Adjustment procedure must be followed properly!!!
Engine
Cleaning Large Engine Parts
You actually may not need a large tank to thoroughly clean them
Engine
How to Prevent Problems When Your Benz is Stored Over Winter
Do not neglect to give it Kents 30 day exercise program
Engine
Using Silicone RTV Gasket Adhesives
Alert! Use at your own risk
Engine
Gas or Diesel Engine Runs Too Hot or Too Cold
Too Cold think thermostat - too Hot think a number of possible causes
Engine
They Said it Only Needed a Head Gasket!
If the engine has been overheated it is almost never "just a head gasket"
Engine
How to Restore the Paint on Your Black Engine and Chassis Parts
With the right paint and technique YOU can do it yourself!
Engine
Removing Stuck Radiator and Coolant Hoses
An old hose can be very difficult to remove due to age and corrossion
Engine
Dealing with Problem Engine Studs
How to get the frozen nuts off and the stud back in safely
Engine
I Installed a New Timing Chain and It "Jumped" Some Sprocket Teeth
Now the timing marks don't line up - What do I do! - Help...
Engine
Slow Loss of Coolant and Minor Drips Around and Under Radiator or Coolant Tank
Be sure to check your radiator / expansion tank cap
Engine
Keeping Your Engine and Engine Compartment Clean and Detailed
Are you concerned about damage to the electrical components and sensitive electronics?
Engine
Where in the World Can You Get a Good Shop Light?
You may have to make your own like Kent did...:-)
Engine
Removing Rounded Out or Damaged Hex Head Bolts
Avoid the pain of having to drill or cut the bolts off
Engine
Temporary or Emergency Repair Kit Contents? - Especially When on the Road
Here are some of Kent's favorites - most you should carry in your trunk
Engine
Are There Better Shop Work Lights Out There?
Kent has been inspired to design his own series of ultimate shop lights
Engine
Securing Rubber Exhaust System Hangers (Donuts)
They can fall off especially if your exhaust system is sagging or not mounted properly
Engine
Buying a Used Mercedes Quick Check No. 1
Your inspection should always include this
Engine
Cleaning an Old Dirty Oily Diesel Engine
There is a better and cleaner way!
Engine
Rubber Exhaust Hanger ( Donut ) Replacement
These can be a little tricky to get on
Engine
Breaking Free Frozen Hex Bolts: Part 1
At all costs avoid rounding out the hex head of the bolt!
Engine
Removing a Power Steering Pump Pulley
Most often this can be done without special tools using a helper and a heavy hammer
Engine
Gas Engine Runs Rough
Sometimes fuel injector cleaner can work wonders
Engine
Keeping Things in Place - On and Off a Car
This is Kent's favorite
Engine
Avoiding Internal Engine Corrosion
You neglect the maintenance here and you WILL pay the price
Engine
Draining Oil Out of Your Engine
The best way is to use an oil extractor
Engine
Removing a Stubborn Power Steering Pump Pulley
Sometimes they are really stuck on the shaft!
Engine
Throttle Linkages Binding
Ball joints and pivot points should be lubricated on a 6 to 12 month basis
Engine
Inspecting and Replacing Rubber Exhaust Hangers
With the right tool and a little know-how it is super easy.
Engine
Starter Motor Grinds When I Turn the Key - How to Bench Test?
Could be the starter itself, ring gear on the flywheel or a combination of both